Edge Comp Plug-In Module

For 2001 Dodge 5.9L Cummins ISB 24V

^$503.99

SuperTruck Essentials Part No: 77609.555
Manufacturer Part No: 30301

The Edge Comp module maximizes engine efficiency by monitoring the RPM, timing, turbo boost pressure and fueling parameters. The module uses this information to determine and control both fueling and timing enhancements for the Bosch fuel injection pump. Timing and fueling enhancements are controlled via CAN-BUS through the Data Link and by connecting directly into the Bosch fuel injection pump. more...

Installation Notes

Install Time: Less than an hour

Fits these Vehicles

2001 Dodge Trucks

Fits these Engines

Dodge 5.9L Cummins ISB 24V Diesel

Product Details

The Edge Comp features five power levels with power gains from 40-120 horsepower. Each of the five power levels has an independent five-level adjustable responsiveness setting, providing for a total of 25 levels of adjustability! The responsiveness settings enable you to dial-in the optimum balance between responsiveness and low boost smoke control, no matter what additional power modifications have been made to the engine. The Comp module is fully adjustable on the fly and mounts inside the cab.

Sub-levels 1-3 on the Comp will provide de-fueling below stock. The de-fueling mode is entered only when rpm and boost are below a set value and stock fueling is being increased beyond a set rate. These conditions are different for each sub-level 1-3. During operation, when the de-fueling mode is entered, the rate of fueling increase is limited, which reduces smoke. De-fuel mode is exited once stock fueling equals the fueling controlled by the Comp. This way the transition is smooth and cannot be felt while driving. De-fuel mode is entered the easiest in sub-level 1 and has the smallest allowable fuel increase, while sub-level 3 de-fuel mode is not entered as easily and has a larger allowable fuel increase.

Sub-levels 4 and 5 allow adjustment of the additional fueling above stock based on boost level. Sub-level 5 adds the most fuel at low boost; Sub-level 4, which adds less fuel than Sub-level 5, corresponds to jumper setting 2 on the EZ.

The amount of additional fuel added is calculated, the amount actually added after being compared to boost from the total is as shown below:

Sub level 1: 33% is added at 0 psi boost
100% is added at 20 psi boost

Sub level 2: 50% is added at 0 psi boost
100% is added at 15 psi boost

Sub level 3: 67% is added at 0 psi boost
100% is added at 10 psi boost

Fuel may be added at 0 psi boost on all Sub Levels and EZ Jumper settings unless the de-fuel mode is entered as described above.

Power Level 1 on the Comp is the same as the EZ; on Power Levels 2-5 additional power is added via the wire tap onto the injection pump. If the pump wire is not attached with a Comp, Levels 2-5 are still operational, but the power gain is not any higher than Level 1. Under this scenario, however, power will come on much earlier in the throttle

**Legal in California only for racing vehicles which may never be used upon a highway.

K&N Performance Products

Harley Davidson Officially Licensed Products

Jeep Parts

Challenger Parts

Camaro Parts

©1995-2010, Quadratec, Inc. All rights reserved. This entire site with its content is copyright protected. All images are invisibly watermarked and cannot be used without explicit agreement from SuperTruck Essentials.

The terms Quadratec and Essentials are Registered Trademarks of Quadratec Incorporated, Registered in U.S. Patent and Trademark Office. All manufacturersÕ names, numbers, symbols and descriptions are used for reference purposes only, and it is not implied that any part listed is the product of these manufacturers or approved by any of these manufacturers.

All manufacturers' names, numbers, symbols and descriptions are used for reference purposes only. It is not implied that any part listed is the product of these manufacturers or approved by any of these manufacturers. Ford, F-Series, F-100, F-150, F-250 the Blue Oval Logo, and Super Duty are trademarks of the Ford Motor Company. The terms Dodge, Ram, Dakota, and the Ram Head logo are trademarks of Chrysler LLC. GM, Chevrolet, Chevy, Silverado, C/K, Z71, GMC, Sierra, are trademarks of General Motors. SuperTruck Essentials is not affiliated with the Ford Motor Company, General Motors, Chrysler LLC or NASCAR. NASCAR is a registered trademark used for identification purposes only throughout this web site.

Disclaimer: We have made every effort to ensure that the information in this web site is correct; however, any typographical or printing errors, prices or specifications (subject to change) will be corrected without prior notice.

SuperTruck Essentials is a Quadratec company.
Visit our Jeep Parts and Jeep Accessories store at Quadratec.com
Visit our FJ Cruiser Parts, Tacoma Parts & Tundra Parts store.